Gas Furnace Maintenance
Are you looking for gas furnace maintenance in Wayne, IL ? Our heating and furnace service technicians have years of experience working on furnaces like yours in Wayne, IL. has service vehicles on call that are fully equipped with the tools and parts necessary to get your furnace back up and operating.
We offer gas furnace maintenance and maintenance agreements to keep your heating system running great. You can rely on to advise you properly and to do excellent work promptly. Ask us about maintenance agreements for your high efficiency furnace today.
We provide gas furnace Maintenance Agreements in Wayne, IL
Furnace Report:
Furnace Report
• Inducer Amps MNF/ 1.2- Test/
• Clean Flame Sensor
• Blower Motor Capacitor MNF/ 5- Test/3.6 Recommended Replacing Cap
• Inspect Wiring No Issues
• Inspect Burner No Rust
• Inspect Orifices For Blockage Cleared All Ports
• Carbon Monoxide Test 0ppm Found
• Inspect Chimney No Issues
• Inspect Pressure Switch Lines No Issues
• Test Sequence Of Operation No Issues
• Inspect Heat Exchanger No Issues
• Check Ignitor No Issues
• Check/replace The Filter Replaced Air Filter
• Test Gas Shut Off No Issues
• Test Thermostat For Proper Operation No Issues
Shirley , M. Wayne, IL
10-15-2022
Furnace Report:
Furnace Report 1st Floor
• Inducer Mmf/.5 @ .4
• Clean Flame Sensor Sensor Is Cleaned
• Inspect Blower Motor No Issues
• Inspect Wiring No Issues
• Inspect Burner No Issues
• Inspect Orfices For Blockage No Issues
• Carbon Monoxide Test 0ppm
• Inspect Chimney Na
• Inspect Pressure Switch Lines No Issues
• Test Sequence Of Operation No Issues
• Inspect Heat Exchanger No Issues
• Check Ignitor No Issues
• Check/replace Filter Replaced Air Filter
• Test Gas Shut Off No Issues
• Test Thermostat For Proper Operation No Issues
Nicole , L. Wayne , IL
12-14-2021
Upon Arrival, Verified Sequence Of Operation Through Thermostats For Cooling. Tested. Blower Compartment Was Tested And Inspected. I Found Air Filter: 216 Aprilaire Extremely Dirty And I Took Out During Testing. I Completed Maintenance/inspection On Outdoor Unit And Found Everything To Be Between Manufacturing Specifications. Please Reference Tune Up Form For Details. Re Installed Air Filter Downstairs And Let Homeowner Know Air Filter Was Dirty And Needed To Be Replaced Asap. Talked To Homeowner About Older Unit And Declined To Do Clean And Check For Ac At This Time And Just New One.
Humidifier Settings Were Adjusted From Max To Normal And Registered Address To Humidistat To Be Able Register Local Address.
Thomas, M. Wayne, IL
04-02-2024
Upon Arrival, Pre-clean-up Start-up Operations Are Good. Motors Are Working Well Within Amp Rate. The Flame Sensor Is A Bit Dirty, Switches Are Good. Cleaned Up Flame Sensor, Motors Housing, Burner Assembly, The Interior Of The Furnace. The Current Filter Is Good, Recommend Changing It In 2 Months. Offered Humidifier Maintenance & Homeowner Accepted.
Annual Furnace Preventative Maintenance:
Your Fall Preventative Maintenance Includes
- Clean Burner Assembly
- Clean Flame Sensor
- Inspect Heat Exchanger
- Check Igniter
- Test Safety Circuit
- Carbon Monoxide Test
- Check Sequence Operations
- Inspect Blower Motor And Cage
- Measure For Correct Airflow
- Tighten Electrical Connections
- Measure Volts/amps On Motors
- Change Filter
Humidifier Maintenance And Cleaning
Disassemble And Inspect Aprilaire Humidifier
-Clean Drain Assembly
-Clean Distribution Tray
-Clean Water Feed Tube
-Verify Water Flow, Clean Orifice
-Clean Or Replace Drain Tube As Needed
-Verify 24v Control Operation
-Replace Media Filter
Set Manual Controls @ 35% For Winter Opperaion.
Verify Automatic Control Set In WiFi Stat
Shirley , M. Wayne, IL
10-14-2021
